Military Wiki
Terrex ICV
NDP2010 CR3 Terrex ICV 1.JPG
Terrex Infantry Carrier Vehicle
Type Armoured personnel carrier
Place of origin Singapore
Service history
Used by See users
Production history
Designer ST Engineering and Timoney Technology Limited of Ireland
Designed 2004
Manufacturer ST Engineering and Otokar
Produced 2006
Weight 25 tonnes (55,000 lb)
Length 7 metres (23 ft 0 in)
Width 2.7 m (8 ft 10 in)
Height 2.1 m (6 ft 11 in)
Crew 2 (Commander, Driver)
+ 12 troops

Armor Classified, Modular
CIS 40 AGL with 60 rounds
7.62 mm Co-axial with 250 rounds,
CIS SGL with 5 rounds
Engine Caterpillar Inc. C9 inline-six diesel engine
400 horsepower (300 kW)
Power/weight 16 hp/tonne
Suspension 8x8 Hydropneumatic Double wishbone suspension
800 kilometres (500 mi)
Speed 110 kilometres per hour (68 mph)

The Terrex Infantry Carrier Vehicle (ICV) is an armoured fighting vehicle developed by ST Engineering and Timoney Technology Ltd, and produced under license by Turkish automaker Otokar and ST Kinetics (a subset of ST Engineering) as the Yavuz. It weighs an estimated 25 to 30 tonnes on an 8x8 wheeled chassis with modern armour. Multiple weapon platforms are supported, including both the remote and overhead weapons stations.

Production History and Development

The Terrex started off as a private venture between Singapore Technologies Engineering and Timoney Technology, intended for export sales. The prototype Terrex AV81 armoured fighting vehicle that was exhibited for the first time at DSEi 2001.[1] The initial AV-81 design utilised conventional coil springs shock absorbers but later variants have seen the introduction of hydro-pneumatic struts with real-time damping control. An electric-hybrid drive system was also developed.

In mid-2004, one prototype and one pre-production model had been built and was evaluated throughout Asia and Europe, where the vehicle was offered for a number of emerging wheeled armoured vehicle requirements. This was further influenced by the emerging United States' Interim Brigade Combat Team (IBCT) concept, which calls for the need of wheeled armoured fighting vehicles (AFV) as opposed to tracked AFVs.

The Terrex AV-82 was developed in 2005 equipped with a more advanced driveline and hydro-pneumatic suspension system, and a number of changes from the AV81 including a flat underbody instead of a V-shaped hull and revised rear suspension.

The Singapore Armed Forces will acquire at least 135 Terrex ICVs to replace its V-200 armoured vehicles, with all active Infantry and Guards battalions to begin training to operate from the vehicle in February 2010.[2] The Second Battalion, Singapore Infantry Regiment, recently acquired the Terrex as part of its shift into a motorised infantry battalion.[3] The Indonesian Army has plans to purchase 420 units and has also expressed intent to produce the Terrex locally under license. Turkish automaker Otokar has also joined with ST Kinetics to produce the Terrex AV-82 (renamed Yavuz) for the Turkish Armed Forces.[4][5]

Marine Personnel Carrier

In August 2012, the U.S. Marine Corps awarded SAIC a developmental contract for the Terrex for the Marine Personnel Carrier program.[6]

In June 2013, the Marine Corps put development of the Marine Personnel Carrier on hold.[7]

On 18 July 2013, SAIC, along with ST Kinetics and Armatec Survivability Corporation, successfully completed two weeks of evaluations for the Terrex at Camp Pendleton. The tests included a series of water performance demonstrations in various sea conditions and an evaluation of human factors and stowage capacity. The Terrex completed all required surf transit and ocean swim maneuverability tests at its fully loaded combat weight. It demonstrated load capabilities through successful stowage of gear and supplies that Marines would require for three days of operations, with space available for additional equipment. The human factors evaluation demonstrated the spacious interior by accommodating the specified number of combat-equipped Marines and enabling rapid tactical and emergency egress through a quick-release hatch. The Terrex repeated ocean swim and maneuverability results achieved in a March 2013 rehearsal event. SAIC began ballistic and blast tests at the Nevada Automotive Test Center in May 2013, and is scheduled to complete all ballistic and mine blast demonstrations in July. The Marines are to deliver a final report in September 2013.[8]


As with a number of other recent wheeled armoured vehicles, the Terrex is of modular design with various levels of armour protection and weapon systems being marketed up to a gross vehicle weight of 24,000 kg. Along with its size, the Terrex is air portable by C-130s or other similar cargo aircraft.

The Terrex's layout is conventional: the driver sits front left and the power pack is to the right.[9] This leaves the rest of the vehicle clear for the troop compartment, which is provided with a power-operated ramp and roof hatches.[9]

Various weapon systems can be fitted on the roof, including a remote weapon station armed with a 40mm automatic grenade launcher and a 7.62mm coaxial machine gun or a complete stabilized turret armed with a 25mm M242 Bushmaster cannon and 7.62mm coaxial machine gun. Additional 7.62mm machine guns can be mounted over the rear troop compartment. In addition, the vehicle can be configured to carry varying combat payloads - from turreted weapon stations (including 105 mm tank guns) to rocket launchers. The modular top deck allows for quick configuration change.

The Terrex AV-81 uses a patented independent double wishbone suspension, which greatly improves ground mobility and ride comfort over the roughest terrain. The use of automatic traction control and the capacity for large footprint off-road tires enables it to traverse at unprecedented speeds in soft ground conditions.

The vehicle has a double hull with an external V-hull that improves mine blast survivability.[10] Add-on armour provides further protection for troops.[11] It is also capable of providing full Nuclear, Biological and Chemical protection in extreme operational conditions.[10]

Standard equipment includes powered steering on the front four wheels, central tyre-pressure inflation system, anti-lock braking system and nuclear, biological and chemical defensive system, but there are numerous other options.

In its baseline configuration, the AV-81 Terrex is fully amphibious: two water jets mounted on either side at the back of the hull propel the vehicle through water at 10 km/h.


The following are known variants made in service:[12]

  • Command Variant
  • 40mm AGL/7.62mm Coaxial MG Variant
  • .50 calibre HMG Variant
  • SPIKE ATGM Variant
  • Pioneer Variant
  • Medical Variant
  • Reconnaissance, Surveillance, and Target Acquisition (RSTA) Variant
  • STORM Variant


See also


  1. CLAWS OF THE CELTIC TIGER An appendix to: Undermining Global Security The European Union’s Arms Exports, First published in 2004 by Amnesty International, Irish section, Page 15
  2. "Networked infantry carrier vehicle gives SAF sharper edge in urban warfare". cyberpioneer, MINDEF. 2009-09-03. Retrieved 2009-09-09. 
  3. "Operationalisation of the First Motorised Infantry Battalion". Singaporean Ministry of Defense. 2011-05-31. Retrieved 2012-02-08. 
  4. "S'pore, Turkish firms in vehicle project". 2009-10-01. Retrieved 2009-09-09. 
  5. "新加坡研制"特拉克斯"AV81装甲步战车 (Singapore develops "Terrex" AV81 Armoured Fighting Vehicle)". 2003-03-06. Retrieved 2009-09-09. 
  6. Personnel carrier development contracts awarded -, September 10, 2012
  7. Commitment to Swimming Vehicle Throws Off Marines’ Tight Modernization Schedule -, October 2013
  8. Terrex Completes U.S. Marine Corps’ Amphibious Vehicle Evaluation in Camp Pendleton - SAIC press release, 18 July 2013
  9. 9.0 9.1 "Singapore Technologies Kinetics Terrex Infantry Carrier Vehicle (Singapore), Armoured personnel carriers (wheeled)". Jane's. Archived from the original on 2012-02-09. Retrieved 2012-02-09. 
  10. 10.0 10.1 "Terrex Intro". Retrieved 2012-02-09. 
  11. 11.0 11.1 "Terrex". Army Technology. Archived from the original on 2012-02-08. Retrieved 2012-02-08. 
  12. Christopher Foss (2010-02-25). "Combat rock: Singapore gears up for introduction of new 8x8 Terrex ICV". Jane's. Retrieved 2012-02-09. 

External links

Video links

This page uses Creative Commons Licensed content from Wikipedia (view authors).