The DARPA Falcon Project (Force Application and Launch from CONtinental United States) is a two-part joint project between the Defense Advanced Research Projects Agency (DARPA) and the United States Air Force (USAF) and is part of Prompt Global Strike. One part of the program aims to develop a reusable, rapid-strike Hypersonic Weapon System (HWS), now retitled the Hypersonic Cruise Vehicle (HCV), and the other is for the development of a launch system capable of accelerating an HCV to cruise speeds, as well as launching small satellites into earth orbit. This two-part program was announced in 2003 and continued into 2006.
The latest project to be announced under the Falcon banner was a fighter-sized unmanned aircraft called Blackswift which would take off from a runway and accelerate to Mach 6 before completing its mission and landing again. The memo of understanding between DARPA and the USAF on Blackswift—also known as the HTV-3X—was signed in September 2007. The Blackswift HTV-3X did not receive needed funding and was canceled in October 2008.
Current research under FALCON program is centered on X-41 Common Aero Vehicle (CAV), a common aerial platform for hypersonic ICBMs and cruise missiles, as well as civilian RLVs and ELVs. The prototype Hypersonic Technology Vehicle 2 (HTV-2) first flew on 22 April 2010; the second test flew 11 August 2011. Both flights ended prematurely.
Design and development
The aim was always to be able to deploy a craft from the continental United States, which could reach anywhere on the planet within one to two hours. The X-20 Dyna-Soar in 1957 was the first publicly acknowledged program—although this would have been launched vertically on a rocket and then glided back to Earth, as the Space Shuttle does, rather than taking off from a runway. Originally, the Shuttle was envisaged as a part-USAF operation, and separate military launch facilities were built at Vandenberg AFB at great cost, though never used. After the open DynaSoar USAF program from 1957–1963, spaceplanes went black. In the mid-1960s, the CIA began work on a high-Mach spyplane called Project Isinglass. This developed into Rheinberry, a design for a Mach-17 air-launched reconnaissance aircraft, which was later canceled.
According to Henry F. Cooper, who was the Director of the Strategic Defense Initiative ("Star Wars") under President Reagan, spaceplane projects consumed $4 billion of funding in the 1970s, 1980s and 1990s (excluding the Space Shuttle). This does not include the 1950 and 1960s budgets for the Dynasoar, ISINGLASS, Rheinberry, and any 21st-century spaceplane project which might emerge under Falcon. He told the United States Congress in 2001 that all the United States had in return for those billions of dollars was "one crashed vehicle, a hangar queen, some drop-test articles and static displays". Falcon was allocated US$170 million for budget year 2008.
The overall FALCON (Force Application and Launch from CONtinental United States) program announced in 2003 had two major components: a small launch vehicle for carrying payloads to orbit or launching the hypersonic weapons platform payload, and the hypersonic vehicle itself.
Small Launch Vehicle
The DARPA FALCON solicitation in 2003 asked for bidders to do development work on proposed vehicles in a first phase of work, then one or more vendors would be selected to build and fly an actual launch vehicle. Companies which won first phase development contracts of $350,000 to $540,000 in November 2003 included:
- AirLaunch LLC, Reno Nevada
- Andrews Space Inc., Seattle Washington
- Exquadrum Inc., Victorville California
- KT Engineering, Huntsville Alabama
- Lockheed Martin Corp., New Orleans Louisiana
- Microcosm Inc., El Segundo California
- Orbital Sciences Corp., Dulles Virginia
- Schafer Corp., Chelmsford Massachusetts
- Space Exploration Technologies, El Segundo California
Hypersonic Weapon System
The first phase of the hypersonic weapon system development was won by three bidders in 2003, each receiving a $1.2 to $1.5 million contract for hypersonic vehicle development:
- Andrews Space Inc., Seattle, Wash.
- Lockheed Martin Corp., Lockheed Martin Aeronautics Co., Palmdale, Calif.
- Northrop Grumman Corp., Air Combat Systems, El Segundo, Calif.
Lockheed Martin received the only Phase 2 HWS contract in 2004, to develop technologies further and reduce technology risk on the program.
Follow on hypersonic program
Following the Phase 2 contract, DARPA and the US Air Force continued to develop the hypersonic vehicle platform.
The program was to follow a set of flight tests with a series of hypersonic technology vehicles.
The FALCON project includes:
- X-41 Common Aero Vehicle (CAV): a common aerial platform for hypersonic ICBMs and cruise missiles, as well as civilian RLVs and ELVs.
- Hypersonic Technology Vehicle 1 (HTV-1): a test concept, originally planned to fly in September 2007, now canceled.
- Hypersonic Technology Vehicle 2 (HTV-2): first flew on 22 April 2010, but contact was lost soon after booster separation
- HTV-3X: Blackswift, now canceled
- Small Launch Vehicle (SLV): a smaller engine to power CAVs, now complete
The Hypersonic Cruise Vehicle (HCV) would be able to fly 9,000 nautical miles (17,000 km) in 2 hours with a payload of 12,000 lb (5,500 kg). It is to fly at a high altitude and achieve speeds of up to Mach 20.
The Blackswift was a proposed aircraft capable of hypersonic flight designed by the Lockheed Martin Skunk Works, Boeing, and ATK.
The USAF states that the "Blackswift flight demonstration vehicle will be powered by a combination turbine engine and ramjet, an all-in-one power plant. The turbine engine accelerates the vehicle to around Mach 3 before the ramjet takes over and boosts the vehicle up to Mach 6." Dr. Stephen Walker, the Deputy Director of DARPA's Tactical Technology Office, will be coordinating the project. He told the USAF website,
I will also be communicating to Lockheed Martin and Pratt & Whitney on how important it is that we get the technical plan in place ... I'm trying to build the bridge at the beginning of the program—to get the communication path flowing.
The Falcon program has announced the hypersonic horizontal take-off Blackswift/HTV-3X. It is also launching the HTV-2 off the top of a rocket booster. Falcon seems to be converging from two directions, on the ultimate goal of producing a hypersonic aircraft which can take off and land from a runway in the USA, and be anywhere in the world in an hour or two. Falcon is methodically proceeding toward a Hypersonic Cruise Vehicle. Dr. Walker stated,
We need to fly some hypersonic vehicles—first the expendables, then the reusables—in order to prove to decision makers that this isn't just a dream… We won't overcome the skepticism until we see some hypersonic vehicles flying.
In October 2008 it was announced that HTV-3X or Blackswift did not receive needed funding in the fiscal year 2009 defense budget and had been canceled. The Hypersonic Cruise Vehicle program will continue with reduced funding.
DARPA had two HTV-2s built for two flight tests in 2010 and 2011. The Minotaur IV light rocket is the booster for the HTV-2 with Vandenberg Air Force Base serving as the launch site. DARPA planned the flights to demonstrate thermal protection systems and aerodynamic control features. Test flights were supported by NASA, the Space and Missile Systems Center, Lockheed Martin, Sandia National Laboratories and the Air Force Research Laboratory's (AFRL) Air Vehicles and Space Vehicles Directorates.
The first HTV-2 flight was launched on 22 April 2010. The HTV-2 glider was to fly 4,800 miles (7,700 km) across the Pacific to Kwajalein at Mach 20. The launch was successful, but the first mission was not completed as planned. Reports stated that contact had been lost with the vehicle nine minutes into the mission. In mid-November, DARPA revealed that the test flight had ended when the computer autopilot had "commanded flight termination". According to a DARPA spokesman, "When the onboard system detects [undesirable or unsafe flight] behavior, it forces itself into a controlled roll and pitchover to descend directly into the ocean." Reviews found that the craft had begun to roll violently.
A second flight was launched on 11 August 2011. The unmanned Falcon HTV-2 successfully separated from the booster and entered the mission's glide phase, but again lost contact with control about nine minutes into its planned 30-minute Mach 20 glide flight. Initial reports indicated it purposely impacted the Pacific Ocean along its planned flight path as a safety precaution. Some analysts thought that the second failure would result in an overhaul of the Falcon program.
In July 2013, DARPA decided it would not conduct a third flight test of the HTV-2 because enough data had been collected from the first two flights, and another test was not thought to provide any more usable data for the cost. The tests provided data on flight aerodynamics and high-temperature effects on the aeroshell. Work on the HTV-2 will continue to summer 2014 to provide more study on hypersonic flight. The HTV-2 is the last active part of the Falcon program. DARPA has now changed its focus for the program from global/strategic strike to high-speed tactical deployment to penetrate air defenses and hit targets quickly from a safe distance.
- Boeing X-51
- Prompt Global Strike, a follow on military project
- Rockwell X-30 (National AeroSpace Plane)
- Lockheed Martin SR-72
- US looks for answers after hypersonic plane fails
- FALCON Force Application and Launch from CONUS Broad Agency Announcement (BAA) PHASE I Proposer Information Pamphlet (PIP) for BAA Solicitation 03-35. DARPA, 2003.
- "Falcon Technology Demonstration Program HTV-3X Blackswift Test Bed". DARPA, October 2008.
- Isinglass. astronautix.com
- Cooper Testimony. tgv-rockets.com
- Space Weapons Spending in the FY 2008 Defense Budget. cdi.org
- USAF DARPA FALCON Program. Air-attack.com. Retrieved: 2012-02-05.
- "Falcon Technology Demonstration Program: Fact Sheet"[dead link] . DARPA, January 2006.
- "US hypersonic aircraft projects face change as Congress urges joint technology office". Flight International, 30 May 2006.
- "First Minotaur IV Lite launches from Vandenberg". U.S. Air Force, 22 April 2010.
- "US hypersonic glider flunks first test flight". AFP news agency, 27 March 2010.
- Graham Warwick (24 April 2010). "DARPA's HTV-2 Didn't Phone Home". Aviation Week. http://www.aviationweek.com/aw/blogs/defense/index.jsp?plckController=Blog&plckBlogPage=BlogViewPost&newspaperUserId=27ec4a53-dcc8-42d0-bd3a-01329aef79a7&plckPostId=Blog%3a27ec4a53-dcc8-42d0-bd3a-01329aef79a7Post%3a70769585-4348-4701-889a-f02c58f38314&plckScript=blogScript&plckElementId=blogDest. Retrieved 2012-02-05.
- "Propulsion, Materials Test Successes Put Positive Spin on Falcon Prospects". Aviation Week, 22 July 2007.
- Falcon HTV-2. DARPA
- Warwick, Graham (24 July 2008). "Boeing Joins Lockheed Martin On Blackswift". Aviation Week, 24 July 2008. Retrieved: 28 March 2010.
- Lorenz III, Philip (17 May 2007). "DARPA official: AEDC 'critical' to hypersonics advancement". Arnold Air Force Base. http://www.arnold.af.mil/news/story.asp?id=123053670. Retrieved 28 March 2000.
- Little, Geoffrey. "Mach 20 or Bust, Weapons research may yet produce a true spaceplane". Air & Space Magazine, 1 September 2007.
- DARPA promotional video of HTV-3X
- Trimble, Stephen. "DARPA cancels Blackswift hypersonic test bed". Flight Global, 13 October 2008. Retrieved 28 March 2010.
- Clark, Stephen. "New Minotaur rocket launches on suborbital flight". spaceflightnow.com, 23 April 2010.
- Waterman, Shaun. "Plane's flameout may end space weapon plan". Washington Times, 22 July 2010.
- Waterman, Shaun (25 November 2010). "Pentagon to test 2nd near-space strike craft". The Washington Times. http://www.washingtontimes.com/news/2010/nov/25/pentagon-to-test-2nd-near-space-strike-craft/. Retrieved November 30, 2010.
- Rosenberg, Zach. "DARPA loses contact with HTV-2". Flight International, 11 August 2011.
- "DARPA HYPERSONIC VEHICLE ADVANCES TECHNICAL KNOWLEDGE". DARPA, 11 August 2011.
- Norris, Guy. "Review Board Sets Up to Probe HTV-2 Loss". Aviation Week, 12 August 2011.
- . BBC NEWS, 11 August 2011.
- Darpa Refocuses Hypersonics Research On Tactical Missions - Aviationweek.com, 8 July 2013
- Falcon page on Darpa.mil
- HCV page on Globalsecurity.org
- "Air Drops Dummy Rocket for Darpa's Falcon", Aviation Week,
- "Hypersonics Back in the News" on Defensetech.org
- "Going Hypersonic: Flying FALCON for Defense" and "Air Force Plans Flight Tests Of Hypersonic Vehicle" on Space.com
- "Pentagon Has Far-Reaching Defense Spacecraft in Works", Washington Post, March 16, 2005
- "US hypersonic aircraft projects face change as Congress urges joint technology office", Flight International, 30 May 2006
|This page uses Creative Commons Licensed content from Wikipedia (view authors).|